SAIB: CE-10-49

SAIB: CE-10-49

SPECIAL AIRWORTHINESS INFORMATION BULLETIN
SAIB:
CE-10-49
SUBJ: Equipment/Furnishings –Drain Mast Heater
Date:
September 23, 2010
This is information only. Recommendations aren’t mandatory.
Introduction
This Special Airworthiness Information Bulletin (SAIB) is to inform registered owners, operators, and maintenance personnel of an airworthiness concern regarding heated drain masts (P/N 105881) on several Cessna Citation airplanes.
The recommendation included in this SAIB should be considered for all serial numbers for the following Cessna Citation airplanes:
Cessna Model
Citation
510
Mustang
525
CJ, CJ1, CJ1+
525A
CJ2, CJ2+
525B
CJ3
525C
CJ4
550
II, Bravo
560
V, Ultra, Encore, Encore+
650
III, VI, VII
750
X
At this time, the airworthiness concern is not an unsafe condition that would warrant Airworthiness Directive (AD) action under Title 14 of the Code of Federal Regulations (14 CFR) part 39.
Background
During troubleshooting of an unrelated discrepancy on a Cessna Model 750 airplane, maintenance personnel smelled a burning odor. Upon further inspection, maintenance personnel found the heated galley drain mast (P/N 105881) self sustaining a fire. The fire was extinguished. Maintenance found the fiberglass heating element had overheated and caught fire. Maintenance personnel replaced the heating element and drain mast.
The national Service Difficulty Reporting System lists four failures of part number (105881) heated drain on three different model aircraft (including the one mentioned above). Three of the failures occurred during ground operation, of which two reported a visible fire and one reported a “discolored fillet fairing”. One of the failures was a new part that failed upon installation.
To address the issue of the drain heaters overheating while being powered on the ground, Cessna will be revising the maintenance manuals for the above-mentioned Cessna airplanes to add procedures for “Safe Ground Maintenance”, which will include procedures for disengaging power to the drain heaters. It is expected that the revision of the maintenance manuals will begin release in Quarter 3 of Year 2010.
1
2
Recommendations
The FAA recommends that owners, operators, and maintenance personnel disengage the power source to the heaters with the above-mentioned part number any time the airplane is on the ground (including when maintenance is done) to ensure longer reliability and avoid failures of the heaters. Until the maintenance manuals revisions are released, you may contact Cessna Aircraft Company for any specific questions regarding the procedures for disengaging the power to the heaters on your specific model.
For Further Information Contact
Christine Abraham, Aerospace Engineer, 1801 Airport Road – Room 100, Wichita, KS 67209; phone: (316) 946-4165; fax: (316) 946-4107; e-mail: This e-mail address is being protected from spambots. You need JavaScript enabled to view it .
For Related Service Information Contact
Cessna Aircraft Company, One Cessna Boulevard, P.O. Box 7704, Wichita, KS 67277; phone: (316) 517-5650.

Dan Weiler
Executive Director of the Cessna Owner Organization
(715) 445-5000, ext. 116
This e-mail address is being protected from spambots. You need JavaScript enabled to view it

Daniel
Executive Director
useravatar
Offline
444 Posts
User info in posts
Only registered users or members can reply or post

Board Info

Board Stats:
 
Total Topics:
6045
Total Polls:
1
Total Posts:
16355
Posts this week:
3
User Info:
 
Total Users:
2542
Newest User:
caseympritchard@hotmail.com
Members Online:
1
Guests Online:
1547

Online: 
daleingle

Forum Legend:

 Topic
 New
 Locked
 Sticky
 Active
 New/Active
 New/Locked
 New Sticky
 Locked/Active
 Active/Sticky
 Sticky/Locked
 Sticky/Active/Locked

ankara escort ankara rus escort ankara escort bayan ankara bayan partner ankara escort kizlar escort ankara ankara escort ankara eskort ankara escort bayan ankara bayan partner ankara escort kizlar escort ankara